Tiger Tank

Tiger I is the common name of a German heavy tank of World War II. The initial official German designation was Panzerkampfwagen VI Ausführung H (abbreviated PzKpfw VI Ausf. H, Ausführung is German for "version") but the tank was redesignated as Panzerkampfwagen VI Ausf. E in March 1943. The tank also had the ordnance inventory designation SdKfz 181.

The Tiger I was in use from late 1942 until the German surrender in 1945. It was given its "Tiger" nickname by Ferdinand Porsche (the roman numeral was added after the Tiger II was produced). The design served as the basis for other armoured vehicles, the Sturmtiger heavy self-propelled gun and the Bergetiger amoured recovery vehicle.

The Tiger's crew training manual, the Tigerfibel, became a souvenir item after WWII
The Tiger differed from earlier German tanks principally in its design philosophy. Its predecessors balanced mobility, protection, and firepower. They were sometimes outgunned by their opponents.

The Tiger I represented a new approach that emphasised firepower and armour at the expense of mobility. Design studies for a new heavy tank had been started in the late 1930s, without any production planning. The real impetus for the Tiger was provided by the quality of the Soviet T-34. Although the general design and layout were broadly similar to the previous medium tank, the Panzer IV, the Tiger weighed more than twice as much. This was due to its substantially thicker armour, the larger main gun, and the consequently greater volume of fuel and ammunition storage, larger engine, and more solidly-built transmission and suspension.

The Tiger I had frontal hull armour 100 mm thick and frontal turret armour of 110 mm, as opposed to the 80 mm frontal hull and 50 mm frontal turret armour of contemporary models of the Panzer IV. It also had 80 mm thick armour on the sides and rear. The top and bottom armour was 25 mm thick; later, the turret roof was thickened to 40 mm. Armour plates were mostly flat, with interlocking construction. The armour joints were of high quality, being stepped and welded rather than riveted.

The tank was too heavy for most bridges, so it was designed to ford four-metre deep water. This required unusual mechanisms for ventilation and cooling when underwater. At least 30 minutes of setup was required, with the turret and gun being locked in the forward position, and a large snorkel tube raised at the rear. Only the first 495 examples were fitted with this deep fording system, all later models were only capable of fording two metres.

The rear of the tank held an engine room flanked by two floodable rear compartments each containing a fuel tank, radiator, and fans. The petrol (gasoline) engine was a 21-litre 12-cylinder Maybach HL 210 P45 with 650 PS (641 hp, 478 kW). Although a good engine, it was inadequate for the vehicle. From the 250th Tiger it was replaced by the uprated HL 230 P45 (23 litres) of 700 PS (690 hp, 515 kW). The engine was in V-form, with two cylinder banks at 60 degrees. An inertial starter was mounted on its right side, driven via chain gears through a port in the rear wall. The engine could be lifted out through a hatch on the hull roof.

The engine drove front sprockets, which were mounted quite low. The eleven-ton turret had a hydraulic motor powered by mechanical drive from the engine. A full rotation took about a minute. The suspension used sixteen torsion bars. To save space, the swing arms were leading on one side and trailing on the other. There were three road wheels on each arm, giving a good cross-country ride. The wheels had a diameter of 800 mm and were interleaved. Removing an inner wheel that had lost its tire (a common occurrence) required several outer wheels to be removed also. The wheels could become packed with mud or snow that could then freeze. Eventually a new 'steel' wheel design, with an internal tire was substituted.

The tracks were an unprecedented 725 mm wide. To meet rail-freight size restrictions the outer row of wheels had to be removed and special 520 mm wide transport tracks installed. With a good crew, a track change took 20 minutes.

The internal layout was typical of German tanks. Forward was an open crew compartment, with the driver and radio-operator seated at the front, either side of the gearbox. Behind them the turret floor was surrounded by panels forming a continuous level surface. This helped the loader to retrieve the ammunition, which was mostly stowed above the tracks. Two men were seated in the turret; the gunner to the left of the gun, and the commander behind him. There was also a folding seat for the loader. The turret had a full circular floor and 157 cm headroom.

The gun breech and firing mechanism were derived from the famous German "88" dual purpose flak gun. The 88 mm Kwk 36 L/56 gun was the variant chosen for the Tiger and was, along with the Tiger II's 88 mm Kwk 43 L/71, one of the most effective and feared tank guns of WW2. The Tiger's gun had a very flat trajectory and extremely accurate Zeiss TZF 9b sights. In British war-time firing trials, five successive hits were scored on a 16"x18" target at a range of 1,200 yards. Tigers were reported to have knocked out enemy tanks at ranges greater than a mile (1,600 m), although most WW2 engagements were fought at much closer range.

Another new feature was the Maybach-Olvar hydraulically-controlled pre-selector gearbox and semi-automatic transmission. The extreme weight of the tank also required a new steering system. Instead of the clutch-and-brake designs of lighter vehicles, a variation on the British Merritt-Brown single radius system was used. The Tiger's steering system was of twin radius type, meaning that two different, fixed radii of turn could be achieved at each gear, the smallest radius on the first gear was four metres. Since the vehicle had an eight-speed gearbox, it thus had sixteen different radii of turn. If a smaller radius was needed, the tank could be turned by using brakes. The steering system was easy to use and ahead of its time. However, the tank's automotive features left much to be desired. When used to tow an immobilised Tiger, the engine often overheated and sometimes resulted in an engine breakdown or fire, for which reason Tiger tanks were forbidden by regulations to tow crippled comrades. The low-mounted sprocket limited the obstacle-clearing height. The tracks also had a bad tendency to override the sprocket, resulting in immobilisation. If a track overrode and jammed, two Tigers were normally needed to tow the tank. The jammed track was also a big problem itself, since due to high tension, it was often impossible to disassemble the track by removing the track pins. It was sometimes simply blown apart with an explosive charge. The standard German Famo recovery tractor could not tow the tank; up to three tractors were usually needed to tow one Tiger.

Although the Tiger I was one of the most heavily armed and armoured tanks of WWII, and a formidable opponent of Allied tanks, the design was conservative and had some serious drawbacks. The flat armour plates were unsophisticated in comparison to the sloped armour of the Soviet T-34, requiring a massive increase in weight to provide for sufficient protection. The tank's weight put severe stress on the suspension, whose complexity made maintenance difficult. The sophisticated transmission system was also prone to breakdowns.

A major problem with the Tiger was its very high production cost. During the Second World War over 40,000 American Sherman and 58,000 Soviet T-34s were produced, compared to 1,355 Tiger I and some 500 Tiger II tanks. The German designs were expensive in terms of time, raw materials and Reichsmarks, the Tiger I costing over twice as much as a contemporary Panzer IV and four times as a Stug III assault gun. [1] The closest counterpart to the Tiger from the United States was the M26 Pershing (around 200 deployed during the war) and IS-2 from the USSR (about 3,800 built during the war)
Henschel & Sohn began development of the vehicle that would eventually become the Tiger I in January 1937 when the Waffenamt requested Henschel to develop a Durchbruchwagen (Breakthrough tank) in the 30 ton range. Only one prototype hull was ever built and it never was mounted with a turret. The Durchbruchwagen I general shape and suspension greatly resembled the Panzer III while the turret would have greatly resembled the early Panzer IV C turret with the short barreled 7.5cm L/24 cannon. Before Durchbruchwagen I was completed a new request was issued for a heavier 30 ton class vehicle with thicker armour.

This was Durchbruchwagen II which would have carried 50mm of frontal armour and mounted a Panzer IVC turret with the 7.5cm L/24 cannon. Overall weight would have been approximately 36 tons. Only one hull was ever built and a turret was not fitted. Development of this vehicle was dropped in Fall of 1938 in favor of the more advanced VK3001(H) and VK3601(H) designs. Both the Durchbruchwagen I and II prototype hulls were used as test vehicles til 1941.

On September 9th 1938 Henschel & Sohn received permission to continue development of a VK3001(H) medium tank and a VK3601(H) heavy tank. The VK3001(H) was intended to mount a 7.5cm L/24 low velocity infantry support gun, a 7.5cm L/40 dual purpose anti-tank gun, or a 10.5cm L/28 artillery piece in a Krupps turret. Overall weight was to be 33 tons. armour was designed to be 50mm on frontal surfaces and 30mm on the side surfaces. Only four prototype hulls were completed for testing. Two of these were used to create the 12.8cm Selbstfahrlafette L/61, also known as Sturer Emil.

The VK3601(H) was intended to weigh 40 tons, carry 100mm on front surfaces, 80mm on turret sides and 60mm on hull sides. The VK3601(H) was intended to carry a 7.5cm L/24, or a 7.5cm L/43, or a 7.5cm L/70, or a 12.8cm L/28 cannons in a Krupp's turret that looked very similar to an enlarged PzIVC turret. One prototype hull was built followed later by five more prototype hulls. The six turrets intended for the prototype hulls were never fitted and ended up being used as static defence's along the Atlantic Wall. Development of the VK3601(H) project was discontinued in early 1942 in favor of the VK4501 project.

German combat experience with the French Somua S35 cavalry tanks, Char B1 heavy tanks, and the Matilda I and Matilda II infantry tanks in June 1940 showed that the German Army's Panzer arm needed a heavier and better armed tank with better armour protection. Superior German tactics overcame the problems with the superior enemy armoured units but the Germans did take notice.

On May 26th 1941, at an armaments meeting, Henschel and Porsche were asked to submit designs for a 45 ton heavy tank to be ready by June 1942. Porsche worked to submit a updated version of their VK3001(P) Leopard tank prototype while Henschel worked to develop an improved VK3601(H)tank. Henschel built two prototypes. A VK4501(H) H1 which used the 88mm L/56 cannon and a VK4501(H) H2 which used the 75mm L/70 cannon.

Unlike the Panther tank, the designs did not incorporate any of the innovations of the T-34: the width benefits of sloping armour were absent but the thickness and weight of the Tiger's armour made up for this.

On June 22nd, 1941 Germany launched Operation Barbarossa, the invasion of the Soviet Union. The Germans were surprised to find themselves opposed by Soviet designs that completely outclassed anything they were currently fielding. These were the T-34 medium tank and the KV-1 heavy tank. The T34 was almost immune to everything but the 7.5cm L/46 PAK40 anti tank gun and the legendary 88 mm gun flak 18/36. Panzer III's with the 5cm L/60 and the 5 cm PaK 38 anti tank guns could penetrate the sides of a T-34 but had to be very close. The KV-1 was immune frontally to all but the 88mm FLAK 18/36.

The emergence of the Soviet T-34 was a great shock; according to Henschel designer Erwin Adlers "There was great consternation when it was discovered that the Soviet tanks were superior to anything available to the Heer". An immediate weight increase to 45 tons and an increase in gun calibre to 88 mm was ordered. The due date for new prototypes was set for 20 April 1942, Adolf Hitler's birthday.

Porsche and Henschel submitted prototype designs and they were compared at Rastenburg before Hitler. The Henschel design was accepted as the best overall design and especially because of the problem-burden Porsche gasoline-electric power unit and its use of large quantities of copper which was a strategic war material. Production of the Panzerkampfwagen VI Ausf. E began in August 1942. Porsche, awaiting orders for his Tiger tank, had built 100 chassis with some of them used for his Tiger prototypes. After not winning the contract it was ordered to use these chassis for a new heavy assault gun/tank hunter. In Spring 1943 ninety-one hulls were converted into the Panzerjäger Tiger (P), also known as Ferdinand, and after Hitler's orders of 1 February and 27 February 1944, Elefant.

The Tiger was essentially still at the prototype stage when first hurried into service, and therefore changes, both small and large, were made throughout the production run. A redesigned turret with a lower, safer cupola was the most significant change. To cut costs, the submersion capability and an external air-filtration system were dropped.

Tigers were capable of destroying the American Sherman or British Churchill IV at ranges exceeding 1,600 m. In contrast, the Soviet T-34 equipped with the 76.2 mm gun could not penetrate the Tiger frontally at any range, but could achieve a side penetration at approximately 500 m firing the BR-350P APCR ammunition. The T34-85's 85 mm gun could penetrate the Tiger from the side at over 1,000 m. The IS-2's 122 mm gun could destroy the Tiger at ranges exceeding 1,000 m from any aspect.

The M4 Sherman's 75 mm gun could not penetrate the Tiger frontally at any range, and needed to be within 500 m to achieve a side penetration. The British 17-pounder as used on the Sherman Firefly, if firing its APDS round, could penetrate frontally at over 1,500 m. The US 76 mm gun, if firing the most common APCBC ammunition, could not penetrate the Tiger frontally at any range, and needed to be within 1,000 m to get a side kill. However, if the 76 mm was firing HVAP ammunition (usually in short supply), frontal penetrations were possible at 1,000 m.

As range decreases in combat, all guns can penetrate more armour (with the exception of HEAT ammunition, which was rare in WW2). The great penetrating power of the Tiger's gun meant that it could destroy many of its opponents at ranges at which they could not respond. In open terrain this was a major tactical advantage. Opposing tanks were often forced to make a flanking attack in order to kill a Tiger. American tank crews were told that the safest and surest way to kill a Tiger was "to get it by its ass"—that is, to manoeuver behind it and hit it in the engine compartment, where the armour was thinnest.

The Tiger was first used in action in September 1942 near Leningrad. Under pressure from Hitler the tank was put into action months earlier than planned and many early models proved to be mechanically fragile. In its first action on 23 September 1942, many of the first Tigers broke down. Others were knocked out by dug-in Soviet anti-tank guns. One tank was captured largely intact, which gave the Soviets a chance to study the tank and prepare a response.

In the Tiger's first actions in North Africa, the tank was able to dominate Allied tanks in the wide-open terrain. However, mechanical failures meant that there were rarely more than a few in action. In a replay of the Leningrad experience, at least one Tiger was knocked out by towed British six-pounder antitank guns.

The tank's extreme weight limited the bridges it could cross and made drive-throughs of buildings which may have had basements risky. Another weakness was the slow traverse of the hydraulically-operated turret traverse mechanism. The turret could also be traversed manually, but this option was rarely used, except probably for a fix of a few mils.

Early Tigers had a top speed of about 45kmh on optimal terrain however this was not a speed recommended for normal operation, and indeed was discouraged in training. Crews were told to not break 2600RPM due to reliability problems of the early Maybach engines at their maximum 3000RPM output. Not long after the Tiger's top speed was reduced to about 38kmh due to the installation of an engine governor capping the RPM of the Maybach HL 230 (HL 210s were used on early models) at 2600RPM. Despite this speed being slower then that of contemporary medium tanks of the time which averaged a top operational speed of about 45kmh, the speed of the Tiger was still very respectable for a tank of its size and weight which was nearly twice that of a Sherman or T-34. The Tiger had reliability problems throughout its service life; Tiger units frequently entered combat understrength due to breakdowns. It was rare for any Tiger unit to complete a road march without losing vehicles due to breakdown. The tank also had poor radius of action (distance a combat vehicle can travel and return, in normal battle conditions, without refueling). Surprisingly, for such a heavy tank, the Tiger had a lower ground pressure bearing than many smaller tanks, the most notable exception being the Soviet T-34.

The Tiger's armour and firepower, however, were feared by all its opponents. In tactical defence, its poor mobility was less of an issue. Whereas Panthers were the more serious threat to Allied tanks, Tigers had a bigger psychological effect on opposing crews, causing a "Tiger phobia". Allied tankers would sometimes evade rather than confront a Tiger, even a tank that only looked like one, such as the Panzer IV with turret skirts applied. In the Normandy campaign, it could take four to five Shermans to knock out a single Tiger tank by maneuvring to its weaker flank or rear armour; the Soviet T-34s fared similarly against the German tanks, as had the German PzIII earlier against the Soviet heavy tanks. An accepted Allied tactic was to engage the Tiger as a group, one attracting the attention of the Tiger crew while the others attacked the sides or rear of the vehicle. Since the ammunition and fuel were stored in the sponsons, a side penetration often resulted in a kill. This was, however, a risky tactic, and often resulted in the loss of several Allied vehicles. It took a great deal of tactical skill to eliminate a Tiger.

Tigers were usually employed in separate heavy tank battalions (schwere-Panzer-Abteilung) under Army command. These battalions would be deployed to critical sectors, either for breakthrough operations or, more typically, counterattacks. A few favoured divisions, such as the Grossdeutschland or some of the low-numbered Waffen-SS divisions had a handful of Tigers.

On 7 July 1943, a single Tiger tank commanded by SS-Oberscharführer Franz Staudegger from the 2nd Platoon of 13th Panzer Company of 1st SS Division Leibstandarte SS Adolf Hitler engaged a group of about 50 T-34s around Psyolknee (the southern sector of the German salient in the Battle of Kursk). Staudegger used all his ammunition in destroying 22 Soviet tanks, while the rest retreated. For this, Staudegger was awarded the Knight's Cross.

On 8 August 1944, a single Tiger commanded by SS-Unterscharführer Willi Fey from the 1st Company of sSSPzAbt 102, engaged a British tank column, destroying some 14 out of 15 Shermans, followed by one more later in the day using his last two rounds of ammunition. sSSPzAbt 102 lost all of its Tigers during fighting in Normandy, but reported 227 Allied tanks destroyed in six weeks.

The Tiger is particularly associated with the name of SS-Haupsturmführer Michael Wittmann of schwere SS-Panzerabteilung 101. He worked his way up, commanding various vehicles and finally a Tiger I. In the Battle of Villers-Bocage, he destroyed over two dozen Allied vehicles including several tanks; and single-handedly held up the advance of the entire 7th armoured Division until his tank was knocked out and abandoned.

Over 10 Tiger tank commanders had over 100 tank kills on their account, including: Kurt Knispel with 168 kills, Otto Carius with 150+ kills, Johannes Bölter with 139+ kills, and Michael Wittmann with 138 kills.

geek     cubicle     dm's    gear